Sealing End Grain Exterior Wood

End grain burns slower than face grain so pay particular attention to the sides of the piece as you go.

Sealing end grain exterior wood.

This product should only be applied to end grains. When feasable adding strips of wood to the end grain gluing or tongue and grooving will hide it and solve the problem. After one coat end grain and spongy areas may still be hungry and insufficiently sealed while denser flat grain areas are starting to build up too much coating. Ideally suited for use as a decking end grain sealer this product is compatible with other products in the osmo exterior wood finishes range.

Sealing wood end grain during a siding deck or trim installation can easily be done and does little to slow down the job. Of course end grain absorbs finish almost as well as water so brushing on the finish will require repeated applications. Ipe seal end grain seal for hardwoods and wood in general is a non toxic waterproofing wax emulsion sealant for fresh cut lumber ends to stop future cracks and splitting. Sand the end grain with an orbital sander with 150g sandpaper give or take a grit just like you would interior stuff and it will last a lot longer.

There s a way around that. Imagine if you were to submerse a piece of wood into sealer letting it absorb all it could at the end grain or spongy areas then remove it and wipe off. Osmo end grain sealing wax is perfect for all exterior wood projects where the end grain requires protection from weathering and water ingress. This is not always possible of course.

It is most widely known to protect wood against end grain checking. Priming and sealing end grain during the wood siding deck or trim installation can be easily accomplished and does little to slow down a job. Spray cans or primer or disposable cans and brushes with primer can be used to prime the end grain once installed. Anchorseal 2 green wood sealer ideal against end grain checking.

Also a commercial solution to even staining it you re doing an on top of the wood finish is to put the stain in your finish i e. End grain checking is the term given to the splinters that you see at the end of wood planks that most often happens right after the wood is. Tinted lacquer varnish etc. All it takes is a little can of paint or sealer.

Because the end grain at the bottom of outdoor furniture legs can wick up water standing on a deck or patio leading to premature rotting you ll have to make extra effort to adequately seal them.